Micro-cide 28 Hld

Micro-Cide 28 HLD, provides an efficient and safe means for the high-level disinfection or sterilization of medical, ophthalmic, dental and surgical devices including endoscopes and lensed instruments. As with all liquid sterilants, this product should be used for instruments and devices that are heat labile or otherwise incompatible with other methods of biologically monitored sterilization.

MICROBIOLOGY: Micro-Cide 28 HLD produces high-level disinfection at room temperature (25C) in as little time as 25 minutes and complete sterilization in 10 hours at room temperature (25C).
Sporicidal Test
Bacillus subtillus
Clostridium sporogenes

Bacteria
Staphylococcus aureus
Salmonella cholerasuis
Pseudomonas aeruginosa

Mycobacteria
Mycobacterium tuberculosis (var: bovis)

Viruses
Herpes simplex virus Type I
Poliovirus Type I
HIV-1 (Associated with AIDS)

Fungi
Trichophyton mentagrophytes

(Studies were performed after 28 days of simulated reuse following prescribed AOAC testing methods).

Clinical / In-Use Studies: Reprocessing flexible fiber endoscopes in use studies supports the effectiveness of Micro-Cide 28 HLD in actual use. (ASTM 1518-94 protocol). In addition, a simulated use-test was conducted to support the contact condition for high-level disinfection of endoscopes at 25C at 25 minutes. The results demonstrate the effectiveness of Micro-Cide 28 HLD to kill M.Terrae dried on flexible fiber endoscopes.

CHEMISTRY: Micro-Cide 28 HLD is an activated glutaraldehyde liquid chemical sterilant and high-level disinfectant. Its active ingredient is glutaraldehyde in a nominal concentration of 3%. When the powdered activator is added, the solution turns green in color to indicate its readiness for use. In addition to the active ingredient, the ready to use solution contains buffers, wetting agents, a rust inhibitor and a pleasant fragrance.

Micro-scientific Industries, Inc. Accessories

Ultrasonic Unit
7-3/4" x 4-1/2" with removable instrument basket that allows for processing small instruments and devices using Opti-Cide solution.

Tonometer Disinfection Tray
Allows for the individual disinfection of contact tonometer tips. Holds 5 tips. Meets current reprocessing recommendations.

4x4 Gauze Dispenser
Spring loaded. 4x4's can be stored dry or saturated with Opti-Cide solution for wiping down equipment and/or surfaces.

2x2 Gauze Dispenser
The same as the 4x4 dispenser, only smaller.

Instrument Soaking Tray
32 ounce soaking tray made of a non-corrosive, high-impact polystyrene plastic and styled with a modern design.

Small Instrument Soaking Tray (not pictured)
Similar to the above, but smaller

Small Round Soaking Tray
A 3"x3", 4 ounce soaking container with a removable basket for disinfection of small items.

Small Instrument Storage Tray
A small 9-1/2" x 6-1/2" x 1-3/4" plastic tray. Clear cover allows visualization of instruments.

Large Instrument Storage Tray (not pictured)
Similar to the above, but 13-1/2" x 9-5/8" x 1-3/4"

Wall Mount Pump Dispenser for use with Opti-Scrub & Opti-Scrub NR 18oz. Bottles (not shown) IMP628-28 Individually

Opti-Kleen Blade Cleaning System Holding Tray

One Gallon Pump Spray Canister used to dispense Opti-Cide solution over large surfaces

Micro-zymetm Detergent

Dual Enzyme Instrument Detergent Concentrate
Specially formulated for the cleaning
of surgical / medical instruments and devices.

Designed for the removal of proteinaceous matter from instruments and medical devices. May be used as pre-soak, manual cleaning, ultrasonic cleaning or used in washer / sterilizer equipment. Micro-Zyme quickly and effectively dissolves blood tissue mucous and other soils.

SAFETY: Special conditioning agents make Micro-Zyme effective in hard or soft water and minimizes scale accumulation on instruments and utensils. This product is safe for use on fiber-optics, flexible endoscopes and other medical instrumentation. Micro-Zyme will not stain instruments and can safely be disposed of down the sink. As with all enzyme products, do not splash into eyes or directly on to skin.

APPLICATIONS: Easy to use. Simply add one to two ounces of Micro-Zyme Concentrate for each gallon of warm to hot tap water. Amount of product depends on soil level. Soak and clean as required. Follow by rinsing.

Opti-cide 3

3-Minute, Ready-To-Use Disinfectant,
Decontaminant & Cleaner for Medical, Dental,
Ophthalmic and Surgical Equipment & Surfaces
Bactericidal Virucidal* Fungicidal Tuberculocidal
(EPA Reg. # 70144-1)

Opti-Cide-3 is a ready to use, highly effective cleaner and disinfectant for use in intensive care and high-risk patient care areas, surgical suites, infant care units, plasma phoresis facilities and other areas where strict environmental control of cross contamination is critical.

Opti-Cide3's non-caustic formula is used to thoroughly clean and disinfect dental, ophthalmic, medical and surgical equipment surfaces such as operating room lights and tables, IV and chest pumps, mayo stands, examination room fixtures, infant incubators, respiratory therapy and anesthesia equipment, laboratory equipment and surfaces as well as other contaminated items.

Opti-Cide-3 may be applied directly to surfaces or used as an immersion solution. Complete instructions for its variety of uses is listed on its label.

MICROBIOLOGY: Opti-Cide-3 kills an exceptionally broad range of disease causing microorganisms with a 3 minute contact time, including::
Gram Positive and Negative Bacteria
Including:
Mycobacterium tuberculosis.(TB)
Staphylococcus aureus
Pseudomonas aeruginosa
Salmonella choleraesuis
Viruses
Including:
*Hepatitis B Virus (HBV)
*Hepatitis C Virus (HCV)
*Influenza A/2 Hong Kong Virus
*Rhinovirus
*Human Immunodeficiency virus (HIV-1)
*Herpes Simplex Virus 1 and 2
*Polio Virus
Pathogenic Fungi
Including:
Trichophyton mentagrophytes

SAFETY: Opti-Cide-3 is safe for use on inanimate surfaces including plastics, stainless steel, chrome, glass, Plexiglas and baked-on painted surfaces. Opti-Cide leaves no residue.

Opti-Cide-3 meets OSHA blood-borne pathogen requirements for disinfection in healthcare facilities and is formulated following strict FDA Good Manufacturing Practices

APPLICATIONS: When used according to label instructions, Opti-Cide-3 is a highly effective:
Surface Disinfectant and Cleaner
Instrument Decontaminant Solution
Ultrasonic Disinfection Cleaning Solution

Opti-lube

INSTRUMENT LUBRICATING RINSE SOLUTION

Ready to Use

DESCRIPTION:

For use on steel and metal surgical instruments prior to steam sterilization. Effectively rinses instrument surfaces removing mineral deposits, disinfectant solutions and residual soil left after cleaning. Applies a very light surgical grade lubrication to instrument surfaces that is absorbed into the instrument surface during the steam sterilization cycle.

APPLICATIONS:
Thoroughly spray or immerse instruments using Opti-Lube Rinse Solution. Leave surfaces wet. Package and /or sterilize according to instrument manufacturers instructions.

SAFETY:
Opti-Lube is non-toxic, non-flammable and non-caustic. No special handling is required. Opti-Lube Instrument Rinse Solution is packaged following strict FDA Good Manufacturing Practices (GMPs).

Opti-scrub

Opti-Scrub
Moisturizing Anti-microbial Hand/Skin Cleanser

Opti-Scrub is a ready to use, highly effective emolliated, anti-microbial hand and skin cleanser. It is especially useful in areas where the control of direct cross-contamination is important.

Opti-Scrub meets OSHA blood-borne pathogen requirements for effective hand washing in healthcare facilities and is formulated following strict FDA Good Manufacturing Practices.

MICROBIOLOGY: Opti-Scrub is effective against a wide range of microorganisms when used as directed, including, but not limited to:
Streptococcous faecalis
Staphylococcus aureus
Salmonella typhosa
Escherichia coli
Pseudomonas aeruginosa
Providencia rettgeri
Bacillus subtilis
Citrobactor Sp
Corynebacterium pryogenes
Enterobacter aerogenes
Klebsieilla pneumoniae
Mycobacterium avium
Enterobacter gergoviae
Proteus mirabilis
Salmonella choleraesuis
Micrococcus luteus
Mycobacterium smegmatis
Proteus vulgaris
Bacillus cereus
Providencia
Acinetobacer calcoaceticus
Serratia marcescens
Aspergillis niger
Penicillium citrinum
Aspergillus flavus
Penicillium chrysogenum
Alternaria solani
Trichophyton rubrum
Trichophyton tonsurans
Epidermophyton floccosum
Saccaromyces bayanus
Candida albicans
Mucor racemosus
Rhizopus stolonifer
Torula ramosa
Pseudomonas cepacia

APPLICATIONS: Opti-Scrub is safe for use as an anti-microbal hand cleanser, a full body skin wash, and may safely be used on the hair or scalp.
The use of Opti-Scrub as a pre-surgical shower and shampoo will significantly reduce microbial skin populations.

SAFETY: Independent studies show that Opti-Scrub is not a primary skin irritant and contains moisturizers, conditioners and skin protectants.

Opti-scrub Nr

Opti-Scrub NR No Rinse Anti-microbial Hand Cleanser and Sanitizer

Opti-Scrub NR is a ready to use, highly effective emolliated, anti-microbial hand and skin cleanser for use when running water is not available. It is especially useful in areas where the control of direct cross contamination is important.
Opti-Scrub NR meets OSHA bloodborne pathogen requirements for effective hand washing in healthcare facilties and is formulated following strict FDA Good Manufacturing Practices.

MICROBIOLOGY: Opti-Scrub NR is effective against a wide range of microorganisms when used as directed, including, but not limited to:
Streptococcus faecalis
Staphylococcus aureus
Salmonella typhosa
Escherichia coli
Pseudomonas aeruginosa
Providencia rettgeri
Bacillus subtilis
Citrobactor Sp
Corynebacterium pryogenes
Enterobacter aerogenes
Klebsiella pneumoniae
Mycobacterium avium
Enterobacter gergoviae
Proteus mirabilis
Salmonella choleraesuis
Micrococcus luteus
Mycobacterium smegmatis
Proteus vulgaris
Bacillus cereus
Providencia
Acinetobacer calcoaceticus
Serratia marcescens
Aspergillis niger
Penicillium citrinum
Aspergillus flavus
Penicillium chrysogenum
Alternaria solani
Trichophyton rubrum
Trichophyton tonsurans
Epidermophyton floccosum
Saccaromyces bayanus
Candida albicans
Mucor racemosus
Rhizopus stolonifer
Torula ramosa
Pseudomonas cepacia

APPLICATIONS: Opti-Scrub NR is safe for use as an anti-microbal hand cleanser and sanitizer in any application. The US Centers for Disease Control (CDC) recommends the use of waterless hand sanitizers on hands free of visible soil between patient contact and before and after gloving.

SAFETY: Independent laboratory studies show that Opti-Scrub NR is not a primary skin irritant. Opti-Scrub NR is formulated to contain moisturizers, conditioners and barrier protectants. Opti-Scrub NR is NON-FLAMMABLE.

Tono-system

Providing the professional eye care specialist with a means of reprocessing contact tonometer tips between eye examinations, following the most current recommendations.

TONO-SYSTEM STARTER KIT (Order no. OSK-001):
1 Tono-Tray
1 quart bottle of Opti-Cide solution
1 box of Opti-Rinse Wipes
1 box of Opti-Kleen Wipes
1 sleeve gauze sponge wipes
1 Directions for Use sheet
1 Instructional Videotape
Descriptions of Individual Kit Components:

Tono-Tray consists of a base with a hinged lid to protect against airborne contamination (i.e. dust, etc.) and to contain evaporation of the disinfectant solution. A separate compartment provides for the storage of disposable cleaning, rinsing, and drying wipes. The tray contains a separate, removable compartmentalized inner tray for individual soaking of up to five tonometer tips. The five sequentally numbered "process" indicators with color coded markers indicate which tonometer tips are "ready for use" and which tips are in the "process of disinfection."
(Order no. TT6-001G)

Opti-Cide Soak is a liquid disinfectant, that when used according to product label directions, meets current criteria for antimicrobial efficacy and is formulated for use on contact tonometer tips and other similar devices.
Packaged: 4-32 oz bottles/box (Order no. OC04-032); 4 boxes per case (Order no. OC16-032)

Opti-Kleen Wipes are individually packaged wipes saturated with a solution to wipe clean the surfaces of tonometer tips prior to disinfection.
Packaged: 100/box; 10 boxes/case. (Order no. OKW10-100B)

Opti-Rinse Wipes are individually packaged wipes saturated with sterile purified USP grade water and used to rinse wipe the surfaces of tonometer tips after disinfection.
Packaged: 100/box; 10 boxes/case. (Order no. ORW10-100W)

Gauze Sponge Wipes made of clean, non-sterile, lint free 2" x 2" gauze are used to dry the surface of tonometer tips after wipe rinsing with Tono-Rinse Wipes.
Packaged: 200/pkg; 25 pkgs per case. (Order no. GS25-200)

Instructional Videotape: A brief video that describes the Tono-System, each of the kit components, and offers a step by step in-service presentation on its proper use. (Order no. TSV-001)